|
|
|
 |
Toyota Certified Used Vehicle (TCUV) 160 Point Inspection |
 |
| 160 Point Quality Assurance Inspection |
At Toyota, only the best of the best are chosen to
be Toyota Certified Used Vehicles. When we choose a vehicle for Toyota
Certification, we have to do a little investigative work. Not only do we put
each vehicle through an exhaustive 160 Point Quality Assurance Inspection,
but we also run a CARFAX Vehicle History Report to ensure it's worthy of
the Toyota Certification process.
Then, each vehicle is reconditioned to
Toyota's exacting standards by factory-trained Toyota Technicians. We want
the vehicles to look and feel as new as possible and we know you do too. We
believe this helps maintain the value, as well as creates pride in ownership
of Toyota Certified Used Vehicles. |
 |
Listed below are the 160 checkpoints. Only vehicles
that pass all 160 checkpoints
(as appropriate to vehicle content) can
receive the Toyota Certified Seal of approval. |
Audio & Alarm Systems
Battery System
Braking System
Emissions & State Inspection
Engine Compartment
Engine Coolant & HVAC System
Exterior Condition & Appearance
Frame, Structure & Underbody
Hybrid Components |
Instrument Panel & Electronic Systems
Interior Condition & Appearance
Lighting Systems
Steering System
Tires & Suspension System
Transmission/Transaxle
Trunk Compartment & Spare
Vehicle History
Additional Items, Where Applicable |
AUDIO & ALARM SYSTEMS
Audio/cassette/CD system working normally, CD cartridge present (if
equipped)
Antenna is present and functions properly
Radio speakers do not rattle at high volume
Remote entry system works properly
Theft-deterrent system works properly
|
BATTERY SYSTEM
Battery in good condition, has proper cold cranking amps and reserve
capacity
Battery proper size and secure
Battery posts free of corrosion
Cables in good condition
|
BRAKING SYSTEM
Inspect brakes, calipers, lines and hoses
No excessive vibration during braking
ABS operates on "panic stop"
Parking brake sets and holds vehicle
Brake pads/shoes must have minimum of 50% wear remaining
No excessive grooving or heat checking of rotors or drums
Parking brake releases completely
Brake pedal free play and travel is normal
|
EMISSIONS & STATE INSPECTION
Perform emissions test and/or state inspection, if required
|
ENGINE COMPARTMENT
Change engine oil and filter
Check for evidence of sludge
Inspect for fuel, oil, coolant or other fluid leaks
Engine cold high idle correct
No abnormal engine noise at cold start
Throttle does not stick shut on cold start
Drivability OK during warm-up
Hot drivability OK
Engine reaches normal operating temperature
Engine fan functions properly
No excessive drone or vibration from engine
Drive belts and hoses free of cracks or damage
No damage to engine mounts
Check under-hood labels and decals
Engine compartment is clean
Under-hood heat insulator pad is clean
Engine free of excessive dressing
Inspect air filter
Oil, brake, clutch, transmission, transfer case, washer and power steering
fluid levels OK
Under-hood fluids clear and uncontaminated
|
ENGINE COOLANT & HVAC SYSTEM
Engine coolant at proper hot and cold levels
Coolant specific gravity to -31° Fahrenheit
A/C cooling operation normal
A/C refrigerant sight glass clear
Heater operation normal
|
EXTERIOR CONDITION & APPEARANCE
Exterior is clean and free of road residue
No cracked or broken lenses of exterior lights
Outside rearview mirror operates/lens is good
Glass free of cracks, stars and large chips
Glass is free of improper repairs
Bumpers are free of cuts, gouges and scratches
Body is free of all dents
Body is reasonably free of dings
Paint is reasonably free of scratches and chips
Vehicle is free of improper paint repairs or mismatched color
Hood and trunk latches working
Free of water spots
Paint is free of swirl marks
Paint has even, high luster
Paint is free of buffable scratches
Free of wax residue
Wheelwells are clean
Acceptable aftermarket items checked
Removal of unacceptable aftermarket items
|
FRAME, STRUCTURE & UNDERBODY
Frame/Unibody check
Inspect body surface
Inspect panel alignment and fit
Inspect lower body and underbody for damage
Check exhaust systems and hangers
|
HYBRID COMPONENTS
Hybrid Vehicle Immobilizer System
Multi-Information Display
Inverter Coolant Level
Engine and ECT (Electronically Controlled Transmission)
ABS (Anti-lock Brake System)
EMPS (Electric Motor Assisted Power Steering)
CCS (Cruise Control System)
SRS (Supplemental Restraint System) Airbag
HV ECU (Hybrid Vehicle Electronic Control Unit)
HV (Hybrid Vehicle) Battery
Perform "Onboard Equalizing Charge" of HV Battery using Intelligent Tester
Fully charge 12-Volt Auxiliary Battery
Clean or replace Air Refiner Filter (A/C or evaporator filter)
Check Transaxle "Park" Mechanism
|
INSTRUMENT PANEL & ELECTRONIC SYSTEMS
Master key is present
Fuel gauge reads correctly
Battery voltage gauge reads correctly
Horn works
Airbag deployment/replaced airbag
Speedometer and odometer work properly
Cruise control operation normal
Clock keeps time
All wiper speeds work correctly
Windshield washer operates
Wiper blades are in good condition and work
Wipers return to correct position when OFF
All mirrors have full range of adjustment
Windows operate normally
Window locks operate normally
Power windows operate from master switch and all door switches
Memory seat control operates properly
|
INTERIOR CONDITION & APPEARANCE
Day/night mirror operates and lens is good
Window tinting clear and free of bubbles
Cigarette lighter is intact and operates
Ashtrays function and are in good condition
Ashtrays and lighter are clean; no evidence of use
Headliner, sun visors, dash pad, upholstery, console, cup holders, trim
panels, floor mats and carpets are in place and in good condition
Cup holder extends completely and sturdily
Doors open and close correctly
Door locks, including child safety locks, work properly
Seats, including all position adjusters, work properly
Headrests function properly
Rear defogger grid lines intact
Interior leather, vinyl, plastic, carpet and fabric surfaces are free of
holes, rips, tears, excessive wear or fading
No evidence of previous improper repairs
Inspect seatbelt condition
Seatbelts have full range of extension and smooth operation
Seatbelts lock up per specification
Inside remote release operates normally
Interior is free of debris
Dash and vents are clean and properly dressed
All crevices are clean
Doorjambs are clean
Glove box and console compartments are clean
Seats, carpets, floor mats and headliner are free of stains
Free of odor, including heavy perfume
Glass is clean and free of streaks
|
LIGHTING SYSTEMS
Warning lights function
High and low beams OK
Headlight aim is OK
Taillights work
Brake lights work
Side marker lights work
Backup lights work
License plate lights work
Instrument lights work
Heater lights work
Dash light dimmer works
Turn signals operate correctly and self-cancel
Four-way flashers work
Defogger indicator light turns on with switch ON
Dome/courtesy lights operate with door cycles
|
STEERING SYSTEM
Steering has normal feel in lock-to-lock turning
Steering wheel centered in straight line driving
Vehicle tracks and drives straight on level surface
Tilt steering wheel adjustment works properly
No excessive wind whistle or buzz
No excessive tire vibration or steering wheel shimmy at any speed
Interior free of significant squeaks or rattles
Inspect steering rack, linkage, bushings, control arms and dust boots
|
TIRES & SUSPENSION SYSTEM
Inspect tires for defects, damage and inflation
Minimum of 5/32" tread depth remaining across tread width
All four tires must be of same brand, model, size, tread design, speed and
load rating
Wheels are clean and free of brake dust
Tires are dressed, not greasy
Wheel cover caps secure with no damage
Inspect struts/shocks for leaks and wear
No damage to CV joints/boots
|
TRANSMISSION/TRANSAXLE
Transmission/clutch operates smoothly
Automatic transmission in "ECT" power mode shifts properly
Transmission gear ranges engage promptly while shifting when warmed up
Transmission shift lock and key interlock system OK
Transmission does not shift into overdrive when button is in OFF position
Inspect transmission case and pan for leaks
No damage to drive and axle shafts
Differential fluid level correct
|
TRUNK COMPARTMENT & SPARE
Trunk is clean, free of debris, no stains
Trunk light and trunk trim appearance
Jack and tools are correct, present and secured
Fiber board tire cover is not broken/warped
Spare tire present
Spare tire and storage areas are clean
Spare tire is securely fastened
No signs of damage to spare tire
Minimum 5/32" tread remaining on spare
Spare tire has correct air pressure
|
VEHICLE HISTORY
Run and print a CARFAX Vehicle History Report [4] /Check for outstanding
Special Service Campaigns
|
ADDITIONAL ITEMS, WHERE APPLICABLE
"Fade-away" dome light works properly
Sunroof/convertible top operates normally through full range of positions
Convertible top lockout function operates
Radio security codes cleared
Navigation system works properly
Transfer case smoothly switches from 2WD to 4WD and back from 4WD to 2WD
Truck bed is in good condition
Truck bedliner is in good condition and secured
Tailgate functions properly
Rear bumper is in good condition and secured
|
|
Beaverton Toyota: Portland, Wilsonville, Gladstone, Gresham, Hillsboro, Salem, Bend, Eugene, Oregon, OR, Vancouver, Washington, WA - New Toyota Certified Used Car
 |
|
Contact Us |
Live Chat |
Employment |
Service/Parts |
Directions |
Accessories |
Rent a Car |
Beaverton Toyota-Scion (Portland, Oregon -
new Toyota,
Toyota Certified Used &
used car dealer - for over 38 years) has sold
new Toyota-Scion;
Toyota
Certified Used;
Accessories &
Parts &
Toyota Rent-a-Car +
Beaverton Toyota-Scion is a nationally ranked
Toyota-Scion Service,
Accessories &
Parts dealer.
|
Buy Toyota-Scion new cars,
certified cars &
used cars on-line at Beaverton Toyota-Scion, a
Portland Oregon area Toyota-Scion dealer. You can browse our entire on-line new, certified & used car inventory & get a
"Quick-Quote"
from this Portland Oregon area ( Portland, Wilsonville, Gladstone, Gresham, Hillsboro, Vancouver, Clark County, Bend,
Eugene, McMinnville, Salem, Rose Quarter) Toyota-Scion dealership. Check out our latest
new car specials,
certified used specials &
used car specials,
accessories specials,
parts specials &
auto repair service specials.
When you get ready to buy a car, Beaverton Toyota-Scion wants to help. Whether coming from
Rose Quarter, Salem, McMinnville, Eugene, Bend, Clark County, Vancouver, Hillsboro, Gresham, Gladstone, Wilsonville, Portland -
save time & money buying a car through our on-line Portland Oregon Toyota-Scion dealership.
We sell & service all new Toyota cars ( Avalon, Camry, Camry Hybrid, Corolla,
Matrix, Prius, Solara, Yaris) & all new Toyota Hybrids ( Camry Hybrid, Highlander
Hybrid, Prius Hybrid) & all new Toyota minivans ( Sienna, Sienna CE, Sienna LE,
Sienna XLE) & all new Toyota SUVs ( 4Runner, FJ Cruiser, Highlander, Highlander
Hybrid, Landcruiser, RAV4, Sequoia) & all new Toyota trucks ( 4x2, 4x4,
Prerunner, Tacoma, Tundra, Xrunner). Beaverton Toyota partners with
Kelley Blue Book for on-line used car trade-in valuations;
Toyota Motor Sales, USA, Inc for product information;
Toyota Financial Services for Lease & Finance programs;
Credit Union Direct Lending (
CUDL) for credit union member vehicle purchases;
Toyota Rent a Car for car rental options; the
state of Oregon -
Dept of Energy - Transportation for
hybrid vehicle tax credits;
American Automobile Association - Oregon/Idaho (
AAA),
American Association of Retired Persons (
AARP),
Intel,
Nike,
Tektronix (
TEK) for Beaverton Toyota Rent a Car member & employee discounts;
AutoTrader,
Buy a Toyota,
Carfax,
Cars.com,
CarSoup,
Costco,
Costco Auto,
Craig's List,
Craig's List - Portland,
Portland Craig's List Cars & Trucks,
Dealer Fusion,
I Make News Inc (
IMN Inc),
Outsell,
Oregonian,
Oregon Live,
Reynolds Web Solutions,
Scion Corp,
Toyota Corp,
Tundra Solutions,
Vantage Club,
Vehix &
Who's Calling for Consumer Inquiries & Customer Satisfaction.
Additionally, we sell & service all certified used Toyota trucks ( Xrunner,
Tundra, Tacoma, Prerunner, 4x4, 4x2) & all certified used Toyota SUVs ( Sequoia,
RAV4, Landcruiser, Highlander Hybrid, Highlander, FJ Cruiser, 4Runner) & all
certified used Toyota minivans ( Sienna XLE, Sienna LE, Sienna CE, Sienna) & all
certified used Toyota hybrid ( Prius Hybrid, Highlander Hybrid, Camry Hybrid) &
all certified used Toyota cars ( Yaris, Solara, Prius, Matrix, Corolla, Camry Hybrid, Camry, Avalon).
Each car listed on our website includes
Toyota-
Scion detailed specs, prices, mileage, pictures & more.
Good credit, no credit & bad credit "2nd Chance Special Finance" auto loan specialists are here to help you
apply for an auto loan, regardless of your situation. Your local
Portland Oregon area Toyota-Scion dealer serving the greater (
Bend, Clark County, Eugene, Gladstone, Gresham, Hillsboro, McMinnville, Portland, Rose Quarter, Salem, Vancouver, Wilsonville) metro area has a full service
Toyota car repair facility & a full selection of
Toyota-Scion accessories & car parts.
Schedule an appointment today & order your Toyota accessories & car parts here.
If you want help finding your dream car, our Portland Oregon area (
Clark County, Vancouver, Portland, Rose Quarter, Gresham, Gladstone, Wilsonville, Hillsboro, McMinnville, Salem, Bend, Eugene
) Toyota-Scion Web site also provides you with an excellent layout of all the
Toyota-Scion models. Our certified Toyota-Scion Portland Oregon area Customer Service Team takes pride in exceeding all our customer's expectations.
You can contact our Internet Department at 888.536.1305, request information on-line, or stop by our Portland Oregon area Toyota-Scion dealer location during normal business hours. Beaverton Toyota-Scion wants to help you with all your auto needs; so use our
website to start your
Toyota-Scion new car,
certified used or
used car search today & please call for further information! |
|
|
For nearly 40 years, Beaverton Toyota-Scion has been selling & servicing Toyota New Cars, Minivans, SUVs & Trucks + Toyota Certified Used Cars, Minivans, SUVs & Trucks in Portland, Eugene, Salem, Gresham, Hillsboro, Bend, McMinnville, Milwaukie, Wilsonville, The Dalles, Gladstone, Oregon as well as Vancouver, Clark County & SW Washington
Beaverton Toyota-Scion | 4300 S.W. Murray Blvd. -- Portland, OREGON -- 97005 (Beaverton) | Sales 888.536.1305 |
| - Site Map - | | | | | | | | -
Site Map - |
| | | | -- Employee Links -- | | | | |
| | | | | | | | | |
